1986 Audi 5000 Recalls

1. Recall Description

   THESE BRAKE HOSE ASSEMBLIES HAVE INADEQUATE CRIMPS ATTACHING THE HOSE TO THE HOSE FITTINGS AND COULD CAUSE THE HOSE AND FITTING TO SEPARATE.

   Possible Effects

   IF THE BRAKE HOSE ASSEMBLY SEPARATES, LOSS OF BRAKING POWER CAN OCCUR INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

   Action

   THESE BRAKE HOSE ASSEMBLIES WILL BE REPLACED.

   Notes

   SYSTEM: BRAKES; HYDRAULIC; LINES; HOSES.EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE HOSE ASSEMBLIES, MODEL SP6957, FOR USE ON 1983 THROUGH 1986 AUDI 5000 VEHICLES.NOTE: THE VEHICLE OWNER SHOULD IMMEDIATELY RETURN THE VEHICLE TO THE SERVICE FACILITY WHICH PERFORMED THE INSTALLATION AND THE INSTALLER SHOLD REMOVE THE BRAKE HOSE ASSEMBLY AND REPLACE IT WITH ASSEMBLY SP9037.EIS WILL REMEDY THE DEFECT WITHOUT CHARGE TO THE OWNER FOR THE REPLACEMENT OF THE DEFECTIVE PARTS AND WILL PAY THE INSTALLING FACILITY FOR ITS PURCHASE COST OF THERE PLACEMENT PART (A COPY OF THE PURCHASE INVOICE WILL BE NEEDED) PLUS A LABOR CHARGE. OWNERS OR INSTALLERS CAN CONTACT EIS AT 129 WORTHINGTON RIDGE, BERLIN, CONNECTICUT 06037, ATTN. D. J. DUPREY, QUALITY ASSURANCE MANAGER, OR CALL1-203-828-8290. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-800-424-9393.

   Recall Manufacture Dates

   1987-01-01 - 1995-12-01

   Vehicles Affected

   414

2. Recall Description

   THE DIFFERENTIAL OIL OF THE TRANSAXLE IS LOST OVER TIME DUE TO EVAPORATION. LOW OIL LEVELS CAUSE PREMATURE BEARING AND GEAR WEAR AND EVENTUAL FAILURE OF THE DIFFERENTIAL.

   Possible Effects

   IN THE EVENT OF FAILURE, THE VEHICLE''S DRIVE WHEELS COULDLOSE POWER. IN EXTREME CIRCUMSTANCES, THE FRONT WHEELS LOCK, CAUSING RAPIDDECELERATION RESULTING IN POSSIBLE LOSS OF VEHICLE CONTROL AND AN ACCIDENT.

   Action

   DRAIN AND REPLACE THE DIFFERENTIAL GEAR OIL WITH OIL HAVING HIGHER PERFORMANCE CHARACTERISTICS.

   Notes

   SYSTEM: POWER TRAIN.VEHICLE DESCRIPTION: PASSENGER CARS WITH AUTOMATIC 3-SPEED TRANSMISSIONS.

   Recall Manufacture Dates

   1984-10-01 - 1991-01-01

   Vehicles Affected

   152000

3. Recall Description

   FUEL INJECTION SEALS MAY HARDEN, DUE TO HIGH TEMPERATURE AND ALCOHOL IN SOME FUELS, AND ALLOW FUEL TO ESCAPE INTO THE ENGINE COMPARTMENT.

   Possible Effects

   FUEL DRIPPING ONTO HOT ENGINE COMPONENTS COULD CAUSE ANENGINE COMPARTMENT FIRE.

   Action

   REPLACE ENGINES FUEL INJECTOR SEALS WITH IMPROVED SEALS PLUS IMPROVEMENTS DESIGNED TO BETTER INSULATE THE ENGINE AGAINST FIRE RISK.

   Notes

   SYSTEM: FUELVEHICLE DESCRIPTION: PASSENGER CARS WITH TURBO.

   Recall Manufacture Dates

   1983-08-01 - 1988-11-01

   Vehicles Affected

   35000

4. Recall Description

   REAR OR FRONT RIGHT SEAT BELT LOCKS MAY NOT PROPERLY ENGAGE. CONSEQUENCE OF DEFECT: SEAT BELTS COULD SEPARATE IN EVENT OF HEAVY BRAKE APPLICATION OR IMPACT AND THUS SUBJECT PASSENGERS TO INJURY.

   Possible Effects

   Action

   REPLACE SEAT BELTS, AS NECESSARY.

   Notes

   SYSTEM: SEAT BELT.VEHICLE DESCRIPTION: PASSENGER CARS.

   Recall Manufacture Dates

   1986-02-01 - 1986-02-01

   Vehicles Affected

   8000

5. Recall Description

   MISADJUSTMENT OF FUEL DISTRIBUTOR ALLOWS FUEL TO ESCAPE AND BE ABSORBED BY THE AIR FILTER. CONSEQUENCE OF DEFECT: WITH THE FUEL ABSORBED BY THE AIR FILTER AND AN ENGINE BACKFIRE ON RESTART, THIS FUEL COULD IGNITE AND RESULT IN AN ENGINE COMPARTMENT FIRE.

   Possible Effects

   Action

   INSTALLATION OF AN AIR FILTER MODIFICATION KIT TO PRECLUDE FUEL LEAKS.

   Notes

   SYSTEM: FUEL/ENGINE COMPARTMENT.VEHICLE DESCRIPTION: PASSENGER CARS.

   Recall Manufacture Dates

   1984-08-01 - 1986-07-01

   Vehicles Affected

   80710

6. Recall Description

   THE IDLE STABILIZER MAY EXPERIENCE EXCESSIVE WEAR, CAUSING ENGINE IDLE FLUCTUATIONS, USUALLY DESCRIBED AS ENGINE SURGE, WHICH INCREASE WITH USAGE OF THE CAR.

   Possible Effects

   ENGINE SURGE COULD ULTIMATELY SEE-SAW TO THE EXTEND THATLOSS OF VEHICLE CONTROL COULD BE EXPERIENCED IF THE BRAKES WERE NOT APPLIED INTIME. THERE IS A RISK OF A COLLISION AND INJURY IN A CONFINED SPACE.

   Action

   REPLACE IDLE STABILIZATION VALVE.

   Notes

   SYSTEM: THROTTLE/IDLE STABILIZER.VEHICLE DESCRIPTION: PASSENGER VEHICLES WITH AUTOMATIC TRANSMISSION.

   Recall Manufacture Dates

   1984-08-01 - 1986-04-01

   Vehicles Affected

   81000

7. Recall Description

   SUDDEN ACCELERATION FROM A STATIONARY POSITION MAY OCCUR, WHEN SHIFTING FROM PARK TO REVERSE OR DRIVE.

   Possible Effects

   UNEXPECTED SUDDEN ACCELERATION WITHOUT PRIOR WARNINGCOULD RESULT IN A VEHICLE CRASH, CAUSING INJURIES.

   Action

   INSTALL AN AUTOMATIC SHIFT LOCK TO PREVENT THE TRANSMISSION SHIFT LEVER FROM BEING MOVED FROM PARK TO REVERSE OR DRIVE UNLESS BRAKE PEDAL IS APPLIED AT THE SAME TIME.

   Notes

   SYSTEM: TRANSMISSION LINKAGE.VEHICLE DESCRIPTION: PASSENGER VEHICLES WITH AUTOMATIC TRANSMISSION.

   Recall Manufacture Dates

   1977-08-01 - 1986-07-01

   Vehicles Affected

   251102

8. Recall Description

   REPEATED TOPPING OFF OF FUEL TANK DURING REFUELING REDUCES THE EXPANSION SPACE WITHIN THE TANK ALLOWING VAPORS TO ESCAPE FROM THE CHARCOAL FILTER TO OUTSIDE RATHER THAN BEING INDUCTED INTO THE ENGINE.

   Possible Effects

   ESCAPING VAPORS COULD IGNITE BY HEAT EMITTED BY THEEXHAUST SYSTEM.

   Action

   INSTALL REDESIGNED FILLER NECK AND A NEW VENT VALVE AND HOSE FOR CHARCOAL FILTER. ALSO, STOP REFUELING WHEN PUMP NOZZLE SHUTS OFF.

   Notes

   SYSTEM: FUEL TANKVEHICLE DESCRIPTION: TURBO AND TURBO QUATTRO PASSENGER CARS.

   Recall Manufacture Dates

   1983-08-01 - 1987-09-01

   Vehicles Affected

   25000

9. Recall Description

   CERTAIN REAR BRAKE CALIPERS COULD BIND AND CONSEQUENTLY OVERHEAT.

   Possible Effects

   OVERHEATED CALIPERS COULD CAUSE BRAKE PEDAL TO FEELSPONGY AND COULD RESULT IN ONE BRAKE CIRCUIT BECOMING INOPERATIVE. BRAKINGABILITY WOULD BE AFFECTED.

   Action

   REQUIRES INSPECTION OF BRAKE CALIPERS AND REPLACEMENT OF CALIPERS AS NECESSARY.

   Notes

   SYSTEM: REAR BRAKE CALIPER.VEHICLE DESCRIPTION: PASSENGER CARS

   Recall Manufacture Dates

   1985-12-01 - 1986-12-01

   Vehicles Affected

   16000