1978 Ford F350 Recalls

1. Recall Description

   THESE VEHICLES MAY BE EQUIPPED WITH STEERING LINKAGES ON WHICH COTTER PINS MAY NOT HAVE BEEN INSTALLED ON CASTELLATED NUTS TO SECURE THE STEERING DRAG LINK AND TIE-ROD CONNECTIONS. ALSO, THESE ATTACHING NUTS MAY NOT HAVE BEEN TIGHTENED TO SPECIFICATIONS. THIS COULD ALLOW LINKAGE SEPARATION.

   Possible Effects

   Action

   THE DEALER WILL PERFORM NECESSARY CORRECTIONS TO THE STEERING LINKAGE ATTACHMENTS.

   Notes

   VEHICLE DESCRIPTION: LIGHT TRUCKS.SYSTEM: STEERING; DRAG LINK.CONSEQUENCES OF DEFECT: SHOULD SEPARATION OCCUR, LOSS OF STEERING CONTROL ANDAN ACCIDENT COULD OCCUR.

   Recall Manufacture Dates

   1978-04-01 - 1978-04-01

   Vehicles Affected

   77

2. Recall Description

   THE DRIVER"S SIDE SHOULDER BELT RETRACTOR MOUNTING BRACKET ASSEMBLY CONTAINS A WELD NUT WHICH WAS IMPROPERLY ATTACHED TO THE BRACKET. THIS FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES".

   Possible Effects

   Action

   THE DEALER WILL REPAIR THE LEFT SIDE SHOULDER BELT RETRACTOR MOUNTING BRACKET ON THE INVOLVED VEHICLES FREE OF CHARGE.

   Notes

   VEHICLE DESCRIPTION: LIGHT TRUCKS.SYSTEM: INTERIOR; RESTRAINT ANCHORAGE.CONSEQUENCES OF DEFECT: IN THE EVENT OF A VEHICLE COLLISION, THE SHOULDER BELTMAY NOT ADEQUATELY RESTRAIN THE DRIVER AND THE CHANCES OF INJURY WOULD BEINCREASED.

   Recall Manufacture Dates

   1977-11-01 - 1977-11-01

   Vehicles Affected

   7

3. Recall Description

   THE SHIFT SELECTOR REACTION SPRINGS MAY BE DEFORMED AS A RESULT OF IMPROPER INSTALLATION OF SELECTOR LEVERS DURING COLUMN BUILDUP. THUS THE LEVER MAY NOT BE ABLE TO BE MOVED INTO THE INSERT DETENTS LOCATED IN THE STEERING COLUMN ASSEMBLY. THIS COULD PREVENT THE "PARK" GEAR FROM BEING ENGAGED.

   Possible Effects

   Action

   DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE SHIFT SELECTOR REACTION SPRING WITHOUT CHARGE TO OWNER.

   Notes

   VEHICLE DESCRIPTION: LIGHT TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSION ANDOPTIONAL TILT STEERING.SYSTEM: POWER TRAIN; TRANSMISSION SHIFT SELECTOR.CONSEQUENCES OF DEFECT: IF THE PARKING GEAR IS NOT ACTUALLY ENGAGED AND THEVEHICLE IS PARKED ON AN INCLINE WITHOUT APPLYING THE EMERGENCY BRAKE, THEVEHICLE COULD ROLL FREE. PROPERTY DAMAGE AND PERSONAL INJURY TO BYSTANDERSCOULD RESULT.

   Recall Manufacture Dates

   1977-08-01 - 1977-12-01

   Vehicles Affected

   47339

4. Recall Description

   SOME OF THE INVOLVED VEHICLES MAY HAVE DEFECTIVE CARBURETORS IN WHICH, UNDER CERTAIN CIRCUMSTANCES, THE SECONDARY THROTTLE PLATES MAY STICK OPEN.

   Possible Effects

   Action

   DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE CARBURETOR AT NO CHARGE TO OWNER.

   Notes

   VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITH 460 CIDENGINES.SYSTEM: THROTTLE LINKAGES; THROTTLE LEVER.CONSEQUENCES OF DEFECT: IN THE EVENT OF THROTTLE STICKING, THE VEHICLE MAYCONTINUE TO ACCELERATE AFTER THE ACCELERATOR PEDAL IS RELEASED. CONTINUOUSACCELERATION COULD OCCUR WITHOUT WARNING AND LEAD TO A LOSS OF VEHICLE CONTROLAND AN ACCIDENT.NOTE: THE LIKELIHOOD OF THE CONDITION OCCURRING CAN BE REDUCED BY AVOIDING FULLOR NEARLY FULL DEPRESSIONS OF THE ACCELERATOR PEDAL AS DURING HIGH ACCELERATIONOR FULL POWER OPERATIONS.

   Recall Manufacture Dates

   -

   Vehicles Affected

   16000

5. Recall Description

   THE WHEEL RIM DIAMETERS ON THESE VEHICLES MAY EXCEED DIMENSIONAL SPECIFICATIONS. THIS MAY CAUSE THE TIRES AND TUBES TO BE OVERSTRESSED DURING MOUNTING OR IMPROPERLY MOUNTED.

   Possible Effects

   Action

   THE DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE WHEELS, AND THE TIRES AND TUBES MOUNTED ON THESE WHEELS.

   Notes

   VEHICLE DESCRIPTION: LIGHT TRUCKS EQUIPPED WITH 16X5.5 INCH TUBE TWO PIECEWHEELS.SYSTEM: SUSPENSION; WHEELS.CONSEQUENCES OF DEFECT: THIS CONDITION MAY RESULT IN TIRE BLOWOUT, SIDE RINGSEPARATION, LOSS OF VEHICLE CONTROL AND AN ACCIDENT. SIDE RING SEPARATION CANALSO ENDANGER PERSONS NEAR THE VEHICLE.

   Recall Manufacture Dates

   1977-11-01 - 1977-12-01

   Vehicles Affected

   9000

6. Recall Description

   THE PITMAN ARM TO STEERING GEAR ATTACHMENT NUTS MAY NOT HAVE BEEN PROPERLY TIGHTENED ON THE INVOLVED VEHICLES. THE NUT COULD COME OFF DURING VEHICLE OPERATION.

   Possible Effects

   Action

   DEALER WILL TIGHTEN THE PITMAN ARM ATTACHING NUT TO THE CORRECT SPECIFICATIONS WITHOUT CHARGE TO OWNER.

   Notes

   VEHICLE DESCRIPTION: LIGHT TRUCKS.SYSTEM: STEERING; PITMAN ARM TO STEERING GEAR ATTACHMENT NUT.CONSEQUENCES OF DEFECT: IF THE NUT COMES OFF, THE PITMAN ARM COULD SEPARATEFROM THE STEERING GEAR, WHICH COULD CAUSE A LOSS OF VEHICLE CONTROL AND ANACCIDENT.

   Recall Manufacture Dates

   -

   Vehicles Affected

   13707

7. Recall Description

   THE INVOLVED VEHICLES WERE BUILT WITH AFT-OF-AXLE FUEL TANKS WHICH WERE NOT AUTHORIZED BY LIGHT TRUCK ENGINEERING. AS A RESULT, THESE VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY", DUE TO POSSIBLE FUEL TANK LEAKAGE WHEN IMPACTED FROM THE REAR.

   Possible Effects

   Action

   DEALER WILL INSPECT AND REPLACE AFT-OF-AXLE FUEL TANK WITH THE CORRECT TANK, WITHOUT CHARGE TO OWNER.

   Notes

   VEHICLE DESCRIPTION: LIGHT TRUCKS EQUIPPED WITH REAR STEP BUMPERS.SYSTEM: FUEL; AFT-OF-AXLE FUEL TANK.CONSEQUENCES OF DEFECT: IN THE EVENT OF A REAR END COLLISION, FUEL LEAKAGECOULD OCCUR AND IF AN IGNITION SOURCE IS PRESENT, A VEHICLE FIRE AND PASSENGERINJURY COULD RESULT.

   Recall Manufacture Dates

   -

   Vehicles Affected

   2

8. Recall Description

   ON THE INVOLVED VEHICLES, LEAKAGE MAY OCCUR AT THE THREADED CARBURETOR-TO-FUEL FILTER CONNECTION ON THE SUSPECT CARBURETORS. THIS IS DUE TO AN IMPROPERLY MACHINED CARBURETOR FUEL INLET CONNECTION.

   Possible Effects

   Action

   DEALER WILL INSPECT AND, IF NECESSARY, WILL REPLACE THE CARBURETOR WITHOUT CHARGE TO OWNER.

   Notes

   VEHICLE DESCRIPTION: LIGHT TRUCKS EQUIPPED WITH 300 CID ENGINES.SYSTEM: FUEL; CARBURETOR.CONSEQUENCES OF DEFECT: IF AN IGNITION SOURCE IS PRESENT WHEN FUEL LEAKAGEOCCURS, A FIRE COULD START AND CAUSE ENGINE DAMAGE AND SERIOUS INJURY TOVEHICLE OCCUPANTS.NOTE: FUEL ODORS MAY INDICATE A LEAK.

   Recall Manufacture Dates

   -

   Vehicles Affected

   30000

9. Recall Description

   ON THE INVOLVED VEHICLES, THE PARK ACTUATION SUPPORT PLATES ARE DEFECTIVE DUE TO THEIR SUSCEPTIBILITY TO CRACKING DUE TO IMPROPER HEAT TREATMENT DURING MANUFACTURE. AS A RESULT, FRAGMENTS FROM A BROKEN PLATE CAN BECOME LODGED IN THE TRANSMISSION PARKING PAWL MECHANISM. THIS COULD PREVENT THE TRANSMISSION PARKING PAWL FROM ENGAGING WHEN THE SELECTOR LEVER IS PLACED IN THE "PARK" POSITION, OR PREVENT THE PAWL FROM BEING DISENGAGED FROM THE PARK GEAR.

   Possible Effects

   Action

   THE DEALER WILL REPLACE THE PARK ACTUATION CAM SUPPORT PLATES, FREE OF CHARGE, ON ALL AFFECTED VEHICLES.

   Notes

   VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITH C-6AUTOMATIC TRANSMISSIONS.SYSTEM: POWER TRAIN; PARK ACTUATION GEAR SUPPORT PLATES.CONSEQUENCES OF DEFECT: IF THE VEHICLE IS PLACED IN THE PARK MODE WITHOUT THEPARKING BRAKE ENGAGED, THE PARKING PAWL MAY NOT ENGAGE THE "PARK" GEAR AND THEVEHICLE WOULD BE ALLOWED TO ROLL FREE CAUSING PROPERTY DAMAGE AND PERSONALINJURIES.

   Recall Manufacture Dates

   1977-10-01 - 1977-10-01

   Vehicles Affected

   19000