1978 Mercury Bobcat Recalls

1. Recall Description

   THE AUTOMATIC LOCKING REAR SEAT BELT RETRACTORS ON CERTAIN VEHICLES MAY FAIL TO LOCK DUE TO BINDING OF THE LOCKING PAWL AGAINST THE RETRACTOR HOUSING. THIS BINDING IS CAUSED BY RETRACTOR HOUSING DEFORMATION WHICH OCCURRED DURING ASSEMBLY. AS A RESULT THE PASSENGERS WOULD BE RESTRAINED ONLY BY THE FULLY EXTENDED BELT. THIS FAILS TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION".

   Possible Effects

   Action

   DEALER WILL INSPECT AND, IF NECESSARY, REPLACE ONE OR BOTH REAR SEAT BELT ASSEMBLIES FREE OF CHARGE.

   Notes

   VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: INTERIOR; REAR SEAT BELT RETRACTORS.CONSEQUENCES OF DEFECT: INADEQUATELY RESTRAINED PASSENGERS COULD BE SERIOUSLYINJURED IN THE EVENT OF AN ACCIDENT.

   Recall Manufacture Dates

   1977-09-01 - 1977-09-01

   Vehicles Affected

   1956

2. Recall Description

   THE FLEXIBLE BLADE ENGINE COOLING FAN BLADES MAY CRACK AND BREAK OFF. THIS MAY BE CAUSED BY HIGH BLADE STRESSES THAT CAN RESULT FROM VIBRATION DURING VEHICLE OPERATION.

   Possible Effects

   Action

   DEALER WILL REPLACE THE DEFECTIVE ENGINE COOLING FAN AT NO COST TO OWNER.

   Notes

   VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 2.8 LITER ENGINES ANDOPTIONAL AIR CONDITIONING.SYSTEM: ENGINE; ENGINE COOLING FAN.CONSEQUENCES OF DEFECT: A BLADE FRAGMENT MAY SEPARATE FROM THE FAN ASSEMBLYWITHOUT PRIOR WARNING. A BROKEN BLADE OR FRAGMENT MAY DAMAGE UNDER-HOODCOMPONENTS.NOTE: IF THE HOOD IS OPEN WHEN BLADE SEPARATION OCCURS, PERSONS NEAR THEVEHICLE COULD BE SERIOUSLY INJURED.

   Recall Manufacture Dates

   1976-08-01 - 1978-07-01

   Vehicles Affected

   83000

3. Recall Description

   CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.

   Possible Effects

   A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.

   Action

   FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.

   Notes

   THIS RECALL ONLY PERTAINS TO AFTERMARKET CARTER, NAPA, ACCUFLOW, TRU FLOW, PARTS MASTER, AND PARTS DEPOT BRAND FUEL PUMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED MOTOR VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

   Recall Manufacture Dates

   -

   Vehicles Affected

   34000