1979 Mercury Zephyr Recalls

1. Recall Description

   THE INVOLVED VEHICLES WERE BUILT WITH SAFETY COMPLIANCE CERTIFICATION LABELS THAT CONTAINED INCORRECT GVWR AND GAWR WEIGHT INFORMATION. THE GVWR"S COULD BE OVERSTATED BY UP TO 197 LBS., DUE TO AN ERROR IN THE REPORTING OF INCREMENTAL OPTION WEIGHTS USED TO DERIVE THE GVWR"S AND GAWR"S.

   Possible Effects

   Action

   THE OWNER HAS THE OPTION OF AFFIXING THE SUPPLIED LABELS HIMSELF OR BRINGING THE VEHICLE IN TO THE DEALER TO HAVE THEM AFFIXED.

   Notes

   VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: EQUIPMENT; CERTIFICATION LABELS.CONSEQUENCES OF DEFECT: IF THE VEHICLE IS LOADED TO THE LARGER RATINGS, VEHICLESTOPPING DISTANCES COULD BE INCREASED AND A GREATER RATE OF TIRE WEAR COULDRESULT, WITH A POTENTIAL FOR A VEHICLE ACCIDENT.

   Recall Manufacture Dates

   1978-08-01 - 1978-11-01

   Vehicles Affected

   9500

2. Recall Description

   THE INVOLVED VEHICLES WERE PRODUCED WITH BRAKE PUSH-ROD TO BRAKE PEDAL RETAINING PINS WHICH WERE NOT HEAT-TREATED AS SPECIFIED. THIS COULD ALLOW THE BRAKE PEDAL TO BECOME DISENGAGED FROM THE PUSH-ROD.

   Possible Effects

   Action

   DEALER WILL REPLACE THE SUSPECT BRAKE RETAINING PIN.

   Notes

   VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SERVICE BRAKES; HYDRAULIC LINKAGE, PEDAL.CONSEQUENCES OF DEFECT: DISENGAGEMENT OF THE BRAKE PEDAL WOULD RESULT IN TOTALLOSS OF SERVICE BRAKES, WHICH COULD LEAD TO LOSS OF VEHICLE CONTROL AND ANACCIDENT.NOTE: THE PARKING BRAKE WILL REMAIN OPERATIONAL EVEN IF SERVICE BRAKES ARELOST.

   Recall Manufacture Dates

   1979-02-01 - 1979-03-01

   Vehicles Affected

   82000

3. Recall Description

   WINDSHIELDS MAY HAVE BEEN INSTALLED ON THESE VEHICLES WITHOUT THE APPLICATION OF A BUTYL PRIMER ON THE MOUNTING SURFACE OF THE GLAZING. THE PRIMER IS REQUIRED TO ENSURE ADEQUATE RETENTION OF THE WINDSHIELD TO ITS OPENING FLANGE. THIS CONSTITUTES A NON-COMPLIANCE WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING".

   Possible Effects

   Action

   DEALER WILL REINSTALL THE WINDSHIELD CORRECTLY WITHOUT CHARGE TO OWNER.

   Notes

   VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: VISUAL; WINDSHIELD RETENTION.CONSEQUENCES OF DEFECT: IN THE EVENT OF AN ACCIDENT, THE WINDSHIELD MAY BECOMEDISPLACED AND THE CHANCES OF PASSENGER INJURY WOULD BE INCREASED.

   Recall Manufacture Dates

   1979-05-01 - 1979-05-01

   Vehicles Affected

   56

4. Recall Description

   CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.

   Possible Effects

   A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.

   Action

   FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.

   Notes

   THIS RECALL ONLY PERTAINS TO AFTERMARKET CARTER, NAPA, ACCUFLOW, TRU FLOW, PARTS MASTER, AND PARTS DEPOT BRAND FUEL PUMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED MOTOR VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

   Recall Manufacture Dates

   -

   Vehicles Affected

   34000