1999 Pontiac Bonneville Recalls

1. Recall Description

   VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 4T65E AUTOMATIC TRANSMISSIONS. THESE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE." A RETAINING CLIP, WHICH SECURES THE MANUAL VALVE TO THE LINKAGE OF THE TRANSMISSION DETENT LEVER, CAN BECOME LOOSE UNDER A COMBINATION OF POSSIBLE DRIVER SHIFTING MANEUVERS AND ALLOW THE LINK TO BECOME DISCONNECTED FROM THE MANUAL VALVE.

   Possible Effects

   IF THE LINK DISCONNECTS, THE DRIVER''S INDICATED PRNDL STATE MAY DIFFER FROM THE HYDRAULIC STATE OF THE TRANSMISSION. IF THE DRIVER SELECTS ''DRIVE'' AND THE TRANSMISSION IS ACTUALLY IN ''REVERSE'', A VEHICLE CRASH COULD OCCUR.

   Action

   DEALERS WILL REPLACE THE MANUAL VALVE/LINK ASSEMBLY WITH A REPLACEMENT MANUAL VALVE/LINK KIT, FEATURING A SPRING-TYPE FASTENER.

   Notes

   OWNER NOTIFICATION BEGAN MAY 25, 1999.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

   Recall Manufacture Dates

   1998-08-01 - 1999-01-31

   Vehicles Affected

   99333

2. Recall Description

   VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CHROME PLATED ALUMINUM WHEELS. SOME OF THESE WHEELS HAVE A MOUNTING SURFACE THAT WAS NOT MACHINED CORRECTLY, CAUSING THE WHEEL STUDS TO BREAK.

   Possible Effects

   THE TIRE/WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE, INCREASING THE RISK OF A CRASH.

   Action

   DEALERS WILL INSPECT THE WHEELS AND REPLACE ALL WHEELS WITH DATE CODES INDICATING THAT THEY MAY NOT HAVE BEEN MACHINED CORRECTLY. THE WHEEL MOUNTING STUDS AT ANY LOCATION WHERE A SUSPECT WHEEL WAS INSTALLED WILL ALSO BE REPLACED.

   Notes

   OWNER NOTIFICATION BEGAN MAY 12, 1999.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

   Recall Manufacture Dates

   1999-02-01 - 1999-03-31

   Vehicles Affected

   352

3. Recall Description

   ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.

   Possible Effects

   THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.

   Action

   DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.

   Notes

   GM RECALL NO. 03054B.SEE CAMPAIGN 03V-473 FOR ADDITIONAL UNITS.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

   Recall Manufacture Dates

   1998-03-01 - 1999-06-30

   Vehicles Affected

   910873

4. Recall Description

   SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

   Possible Effects

   DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

   Action

   SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

   Notes

   THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

   Recall Manufacture Dates

   -

   Vehicles Affected

   16270