1992 Pontiac Sunbird Recalls

1. Recall Description

   VEHICLE DESCRIPTION: PASSENGER VEHICLES. DURING VERY COLD WEATHER, WATER THATN ENTERS THE ACCELERATOR CONTROL CABLE CONDUIT FREEZES AND CAUSES THE ACCELERATOR CABLE TO DEVELOP A HIGH EFFORT OR BINDING CONDITION.

   Possible Effects

   IF THIS OCCURS, LOSS OF NORMAL THROTTLE CONTROL CAN RESULT, OR THE THROTTLE WILL NOT RETURN TO IDLE WHEN THE ACCELERATOR PEDAL IS RELEASED, CAUSING POSSIBLE LOSS OF CONTROL AND AN ACCIDENT.

   Action

   DEALERS WILL REPLACE THE ACCELERATOR CONTROL ASSEMBLY.

   Notes

   NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASE CONTACT PONTIAC SERVICE CENTER AT 1-800-762-2737. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S HOTLINE AT 1-800-424-9393.

   Recall Manufacture Dates

   -

   Vehicles Affected

   108898

2. Recall Description

   THE ACCELERATOR CABLE MAY HAVE BEEN KINKED DURING VEHICLE ASSEMBLY. THE KINK IN THE CABLE CAN CAUSE EITHER A HIGH EFFORT ACCELERATOR CABLE, STICKING ACCELERATOR CABLE, OR A BROKEN ACCELERATOR CABLE.

   Possible Effects

   IF THE ACCELERATOR CONTROL CABLE STICKS OR BREAKS IT CANRESULT IN LOSS OF THROTTLE CONTROL. IF LOSS OF THROTTLE CONTROL OCCURS WHILE THEVEHICLE IS IN MOTION, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.

   Action

   REPLACE THE ACCELERATOR CONTROL CABLE ASSEMBLY.

   Notes

   SYSTEM: ACCELERATOR CONTROL.VEHICLE DESCRIPTION: PASSENGER CAR.

   Recall Manufacture Dates

   1991-03-01 - 1992-01-01

   Vehicles Affected

   22452

3. Recall Description

   THE SECONDARY HOOD LATCH SPRING IS IMPROPERLY INSTALLED OR MISSING, LEADING TO A CONDITION WHERE THE SECONDARY HOOD LATCH DOES NOT ENGAGE THE SECONDARY STRIKER.

   Possible Effects

   IF THE SECONDARY HOOD LATCH IS NOT ENGAGED, AND THEPRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD OPEN UNEXPECTEDLY. IFTHIS OCCURS WHILE THE VEHICLE IS IN MOTION, THE HOOD MAY CONTACT THE WINDSHIELD,REDUCING THE FORWARD VISION AREA OF THE DRIVER AND A VEHICLE CRASH COULD OCCUR.

   Action

   INSPECT HOOD LATCH ASSEMBLIES AND, WHERE NECESSARY, INSTALL A NEW SECONDARY HOOD LATCH SPRING.

   Notes

   SYSTEM: HOOD, LATCH.VEHICLE DESCRIPTION: PASSENGER CARS.

   Recall Manufacture Dates

   1991-08-01 - 1991-08-01

   Vehicles Affected

   3212

4. Recall Description

   SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

   Possible Effects

   DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

   Action

   SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

   Notes

   THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

   Recall Manufacture Dates

   -

   Vehicles Affected

   16270