1987 Jeep Wrangler Recalls

1. Recall Description

   VEHICLE DESCRIPTION: MULTIPURPOSE PASSENGER VEHICLES EQUIPPED WITH PLASTIC FUEL TANKS. THE FUEL TANK SENDING UNIT GASKET CAN CRACK CAUSING FUEL AND FUEL VAPOR LEAKS.

   Possible Effects

   FUEL AND FUEL VAPOR LEAKED FROM THE FUEL TANK CAN RESULT IN FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.

   Action

   REPLACE THE FUEL TANK SENDING UNIT GASKET.

   Notes

   IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASE CONTACT CHRYSLER SERVICE CENTER AT 1-800-853-1403. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-800-424-9393.

   Recall Manufacture Dates

   1986-02-01 - 1993-08-01

   Vehicles Affected

   230000

2. Recall Description

   ON 1987 THROUGH EARLY 1990 MODELS, BOTH FRONT BRAKE HOSES CAN WEAR DUE TO DIRECT CONTACT WITH THE WHEEL OPENING SPLASH SHIELDS. ON THE LATE 1990 THROUGH 1992 MODELS, PERIODIC RUBBING CONTACT OF THE LEFT FRONT BRAKE HOSE CAN OCCUR DUE TO MOVEMENT OF THE SPLASH SHIELD IN CERTAIN VEHICLE OPERATING CONDITIONS.

   Possible Effects

   EITHER CONDITION CAN CAUSE LOSS OF FRONT BRAKE SYSTEMFUNCTIONS, RESULTING IN INCREASED STOPPING DISTANCES AND AN INCREASED RISK OFVEHICLE ACCIDENT.

   Action

   THE 1987 TO 1990 MODEL VEHICLES WILL HAVE BOTH SPLASH SHIELDS REPLACED AND BOTH FRONT BRAKE HOSES REPLACED AS NECESSARY. ALL AFFECTED LATE 1990 THROUGH 1992 MODEL YEAR VEHICLES WILL HAVE ADDITIONAL FASTENERS INSTALLED TO FURTHER SECURE THE LEFT SIDE SPLASH SHIELD. ALSO, THE LEFT FRONT BRAKE HOSE WILL BE INSPECTED AND REPLACED AS NECESSARY.

   Notes

   SYSTEM: BRAKES.VEHICLE DESCRIPTION: UTILITY VEHICLES.

   Recall Manufacture Dates

   1986-02-01 - 1992-07-01

   Vehicles Affected

   280000

3. Recall Description

   THE WHEEL LUG NUTS MAY HAVE BEEN IMPROPERLY TIGHTENED. ALSO, THE STEERING SHAFT CLAMP BOLTS MAY NOT BE PROPERLY TIGHTENED. CONSEQUENCE OF DEFECT: IMPROPERLY TIGHTEN WHEEL LUG NUTS MAY CAUSE THE LUGS TO BREAK AND EVENTUALLY RESULT IN THE WHEEL FALLING OFF. IMPROPERLY TIGHTEN STEERING SHAFT CLAMP BOLT MAY CAUSE COMPLETE LOSS OF STEERING ABILITY. EITHER OF THESE CONDITIONS COULD RESULT IN A LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR WITHOUT PRIOR WARNING.

   Possible Effects

   Action

   PROPERLY TIGHTEN BOTH WHEEL LUG NUTS AND STEERING SHAFT CLAMP BOLTS.

   Notes

   SYSTEM: WHEEL LUG NUTS/STEERING SHAFT/CLAMP BOLTS.VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLE.

   Recall Manufacture Dates

   1986-02-01 - 1986-04-01

   Vehicles Affected

   3333

4. Recall Description

   WINDSHIELD FRAME METAL MAY CRACK AT THE WIPER ARM PIVOT MOUNTINGS DUE TO METAL STRESS DURING WIPER OPERATION.

   Possible Effects

   THIS CAN CAUSE DISLOCATION AND BINDING OF THE WIPERSYSTEM LINKAGE WHICH, IN INCLEMENT WEATHER, COULD AFFECT DRIVER VISIBILITY ANDRESULT IN AN ACCIDENT.

   Action

   RETROFIT WITH A WINDSHIELD FRAME REINFORCEMENT AT THE WIPER PIVOT LOCATIONS AND REDESIGNED LINKAGE COMPONENTS TO REDUCE STRESS AT THE PIVOT MOUNTINGS.

   Notes

   SYSTEM: VISUAL; WINDSHIELD FRAME AND WIPER LINKAGE.VEHICLE DESCRIPTION: MULTI PURPOSE VEHICLES.NOTE: THIS RECALL IS CONTINUED IN NHTSA RECALL 93V150000. THE MANUFACTURERBEGAN INCLUDING A WINDSHIELD FRAME REINFORCEMENT IN ITS VEHICLE PRODUCTION AS OFOCTOBER 13, 1988. 1989 MODELS PRODUCED BEFORE OCTOBER 13, 1988 ARE ELIGIBLE FORTHIS RECALL.

   Recall Manufacture Dates

   1986-02-01 - 1988-07-01

   Vehicles Affected

   75000

5. Recall Description

   CRUISE CONTROL MODULE COULD HAVE INCONSISTENT CRUISE CONTROL OPERATION.

   Possible Effects

   INCONSISTENT CRUISE CONTROL OPERATION COULD RESULT INLOSS OF CONTROL AND AN ACCIDENT.

   Action

   REPLACE MODULE, AS NECESSARY.

   Notes

   SYSTEM: CRUISE CONTROL.VEHICLE DESCRIPTION: MULTI PURPOSE VEHICLES WITH CRUISE CONTROL.

   Recall Manufacture Dates

   1987-01-01 - 1987-02-01

   Vehicles Affected

   3996

6. Recall Description

   BESTOP AFTERMARKET REAR SHELL ROOF RACKS,MANUFACTURED BETWEEN APRIL 27 AND MAY 20, 2004, DESIGNED FOR USE WITH THE BESTOP HARDTOP MADE FOR THE 1986-1995 AND 1997-2003 JEEP WRANGLER. THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK BECAUSE THE LATCH BRACKET MISPOSITIONS THE ROTARY LATCH TO THE COCKPIT COVER. AS A RESULT, THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK AND COULD SEPARATE FROM THE ROOF RACK. THIS RECALL ONLY PERTAINS TO AFTERMARKET REAR SHELL ROOF RACKS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON JEEP WRANGLER VEHICLES BY DAIMLERCHRYSLER.

   Possible Effects

   SHOULD THIS OCCUR, THE COCKPIT COULD CAUSE INJURY BY STRIKING PERSONS OUTSIDE THE VEHICLE OR COULD BECOME A DISTRACTION OR AN OBSTACLE TO OTHER DRIVERS, POSSIBLY RESULTING IN A VEHICLE CRASH.

   Action

   BESTOP WILL NOTIFY ITS CUSTOMERS AND PROVIDE A REPAIR KIT AND INSTALLATION INSTRUCTIONS FREE OF CHARGE. OWNER NOTIFICATION BEGAN JUNE 16, 2004. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BESTOP CUSTOMER SERVICE DEPARTMENT AT (800) 845-3567.

   Notes

   ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

   Recall Manufacture Dates

   -

   Vehicles Affected

   80

7. Recall Description

   CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

   Possible Effects

   WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

   Action

   PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

   Notes

   THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

   Recall Manufacture Dates

   -

   Vehicles Affected

   61944

8. Recall Description

   CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.

   Possible Effects

   A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.

   Action

   FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.

   Notes

   THIS RECALL ONLY PERTAINS TO AFTERMARKET CARTER, NAPA, ACCUFLOW, TRU FLOW, PARTS MASTER, AND PARTS DEPOT BRAND FUEL PUMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED MOTOR VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

   Recall Manufacture Dates

   -

   Vehicles Affected

   34000