1995 Volvo Fe Recalls

1. Recall Description

   VEHICLE DESCRIPTION: CLASS 8 HEAVY DUTY TRUCKS. THE AIR SUSPENSION CONTROL VALVE SUPPLY LINE WAS NOT PLUMBED THROUGH AN AIR PRESSURE PROTECTION VALVE. IN THE EVENT OF A FAILURE, THERE WOULD BE LOSS OF AIR PRESSURE IN THE ''B'' SYSTEM AIR RESERVOIR THAT SUPPLIES AIR PRESSURE FOR THE FRONT STEER AXLE BRAKES.

   Possible Effects

   THIS CONDITION WOULD RESULT IN INCREASED STOPPING DISTANCES.

   Action

   DEALERS WILL INSTALL THE NECESSARY AIR PRESSURE PROTECTION VALVE.

   Notes

   OWNER NOTIFICATION BEGAN DURING NOVEMBER 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

   Recall Manufacture Dates

   1986-10-01 - 1998-07-13

   Vehicles Affected

   95013

2. Recall Description

   THE REAR MOST AXLE OF THE TANDEM AXLE SET COULD HAVE INOPERABLE BRAKES ON ONE OR BOTH WHEELS BECAUSE THE BRAKE S-CAM WAS INCORRECTLY INSTALLED.

   Possible Effects

   THIS CONDITION COULD CAUSE INCREASED STOPPING DISTANCE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

   Action

   DEALERS WILL INSPECT THE BRAKE SYSTEM AND REPAIR THE S-CAM ASSEMBLY IF FOUND REVERSED.

   Notes

   OWNER NOTIFICATION: OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING SEPTEMBER 1996. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO GM HEAVY DUTY TRUCK AT 1-800-528-6586.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-800-424-9393.

   Recall Manufacture Dates

   1995-05-26 - 1995-08-11

   Vehicles Affected

   149

3. Recall Description

   AIR SYSTEM BLOCKAGE IN THE AIR DRYER OCCURS DEGRADING THE MOISTURE REMOVING CAPABILITIES OF THE DRYER WHEN THE VEHICLE IS OPERATED IN A COLD ENVIRONMENT AND MOISTURE ACCUMULATES AND FREEZES IN THE AIR DRYER OR IN THE LINE BETWEEN THE DRYER AND THE AIR SYSTEM RESERVOIR. THE AIR DRYER CAN BECOME OVERPRESSURIZED CAUSING THE AIR DRYER CARTRIDGE TO SEPARATE FROM THE MOUNTING BASE.

   Possible Effects

   IF THE AIR DRYER SEPARATES FROM THE BASE, THE CARTRIDGECAN SEPARATE SUFFICIENTLY ENOUGH TO CAUSE PERSONAL INJURY OR PROPERTY DAMAGE.

   Action

   DEALERS WILL EQUIP AIR SYSTEMS WITH A PRESSURE RELIEF VALVE TO BE LOCATED BETWEEN THE COMPRESSOR AND THE AIR DRYER. THIS PRESSURE RELIEF VALVE IS INTENDED TO VENT IF EXCESSIVE PRESSURE DEVELOPS IN THE AIR DRYER.

   Notes

   SYSTEM: BRAKES; AIR DRYER.VEHICLE DESCRIPTION: HEAVY DUTY CLASS 8 TRUCKS EQUIPPED WITH ROCKWELL WABCO SYSTEM SAVER "1000" AIR DRYER.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, CONTACT VOLVO GM HEAVY TRUCK CORPORATION AT 1-910-279-2000.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-800-424-9393.

   Recall Manufacture Dates

   1993-03-01 - 1995-03-01

   Vehicles Affected

   4709

4. Recall Description

   THE REAR SUSPENSION AXLE RETENTION PLATE CAN BREAK UNDER NORMAL USE, AFFECTING AXLE ALIGNMENT.

   Possible Effects

   THIS CONDITION COULD RESULT IN LOSS OF REAR AXLE STABILITY AFFECTING VEHICLE DIRECTIONAL CONTROL AND INCREASING THE POTENTIAL FOR A VEHICLE CRASH.

   Action

   DEALERS WILL REMOVE AND REPLACE THE AXLE RETENTION CLIP PLATES ON AFFECTED VEHICLES.

   Notes

   SYSTEM: SUSPENSION; SINGLE AXLE; REAR; AIR SUSPENSION. VEHICLE DESCRIPTION: HEAVY DUTY CLASS 8 VEHICLES. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT VOLVO GM HEAVY TRUCK AT 1-800-528-6586. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-800-424-9393.

   Recall Manufacture Dates

   1995-06-01 - 1995-12-01

   Vehicles Affected

   6034

5. Recall Description

   TWO BOLTS ATTACHING THE UPPER STEERING ARM TO THE FRONT STEERING AXLE WERE NOT TIGHTENED PROPERLY.

   Possible Effects

   THE BOLTS COULD LOOSEN INCREASING THE POTENTIAL FOR LOSS OF STEERING CONTROL AND AN ACCIDENT.

   Action

   DEALERS WILL INSTALL NEW BOLTS AND TIGHTEN TO PROPER TORQUE SPECIFICATION.

   Notes

   SYSTEM: STEERING; LINKAGES; ARM.VEHICLE DESCRIPTION: CLASS 8 HEAVY DUTY TRUCKS.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME,SHOULD CONTACT VOLVO GM HEAVY DUTY TRUCK AT 1-910-279-2000. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-800-424-9393.

   Recall Manufacture Dates

   1995-03-01 - 1995-04-01

   Vehicles Affected

   175

6. Recall Description

   THE TRACTION SOLENOID EXHAUST CAN BE OBSTRUCTED DUE TO INADEQUATE DRAINAGE AND A BUILD-UP OF ROAD CONTAMINATION BETWEEN THE MOUNTING BRACKET AND THE SOLENOID HOUSING. THE OBSTRUCTED EXHAUST PREVENTS THE RELAY VALVE CONTROL AIR PRESSURE FROM VENTING AFTER A DIFFERENTIAL BRAKING TRACTION EVENT.

   Possible Effects

   THIS CONDITION WOULD KEEP THE REAR AXLE SERVICE BRAKES APPLIED WITHOUT ANY BRAKE PEDAL MOVEMENT BY THE DRIVER INCREASING THE RISK OF A VEHICLE ACCIDENT.

   Action

   DEALERS WILL REMOVE THE SUSPECT VALVE AND INSTALL A NEW VALVE THAT HAS A MODIFIED SOLENOID HOUSING WHICH WILL ALLOW FOR SUFFICIENT DRAINAGE AND A NEW VALVE MOUNTING BRACKET WITH INCREASED HEIGHT TO REDUCE ENTRY OF CONTAMINATION.

   Notes

   SYSTEM: BRAKES; AIR SYSTEMS. VEHICLE DESCRIPTION: CLASS 8 HEAVY DUTY TRUCKS EQUIPPED WITH A BENDIX ATR TRACTION RELAY VALVE. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT VOLVO GM HEAVY TRUCK AT 1-800-528-6586. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION''S AUTO SAFETY HOTLINE AT 1-800-424-9393.

   Recall Manufacture Dates

   1994-08-01 - 1996-02-01

   Vehicles Affected

   771